i noticed in the Bentleys table of jet sizes for various stock carbs that the main for 34pict was 125, and the main jet for the dual 32s was only slightly smaller..like 120 or thereabouts. So im wondering, if each carb is serving on ly two cylinders, then it is theoretically delivering only half the amount of fuel...so then should not the jet sizes be half the size.? or is the strength of the vacuum on each side that much weaker that the jet size is barely different ? If that is the case, then the ability to atomize the liquid fuel is much less than a centrally located carb.
Herr Colin..what sayest thou ??
jet size question
- dingo
- IAC Addict!
- Location: oregon - calif
- Status: Offline
jet size question
'71 Kombi, 1600 dp
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
- dingo
- IAC Addict!
- Location: oregon - calif
- Status: Offline
Re: jet size question
Well i read that jet size should be 4.1 to 4.3 x venturi size....so dual 32s would each get approx 130 mains....tho the physics of it still escapes my brain
'71 Kombi, 1600 dp
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: jet size question
Think of the entire operating map of a carburetor. It has to provide *not only the maximum fuel* for a given carburetor, but an *appropriate flow for all other loads and speeds.dingo wrote:Well i read that jet size should be 4.1 to 4.3 x venturi size....so dual 32s would each get approx 130 mains....tho the physics of it still escapes my brain
Most of us think of jet sizes like we think of . . . other sizes, and we are stuck on maximums. But what if the jet size has to be proportional to the venturi to maintain the correct fuel-to-air ratio at low air speed as well as higher air speed? Then the above makes sense.
As for dual versus single carburetors, the exact same physics applies. Yes, dual carbs will have lower respective air speeds at idle and low load, but they will and they do flow more air up at the top rpm range.
Therefore, they must have the above proportions to the venturis to draw the correct ratio of fuel to air.
Now ponder that the European dual carburetor 1972 buses had better fuel economy than the 1971 single carb buses.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- asiab3
- IAC Addict!
- Location: San Diego, CA
- Contact:
- Status: Offline
Re: jet size question
What was special about the European dual carb models?Amskeptic wrote: Now ponder that the European dual carburetor 1972 buses had better fuel economy than the 1971 single carb buses.
1969 bus, "Buddy."
145k miles with me.
322k miles on Earth.
145k miles with me.
322k miles on Earth.
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: jet size question
The fact of this superior fuel economy was noted there in a new car review.asiab3 wrote:What was special about the European dual carb models?Amskeptic wrote: Now ponder that the European dual carburetor 1972 buses had better fuel economy than the 1971 single carb buses.
Colin
(it was only 1 mpg, but it was counter-intuitive, thus an interesting factoid)
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles