Vanagon Fuel Pump Ground
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Vanagon Fuel Pump Ground
Does anyone know where does the Vanagon fuel pump ground? My pump is starting to cut in and out. It's not running hot, but it feels like its on its last breath.
Thank you,
Thank you,
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Re: Vanagon Fuel Pump Ground
The book says its at fuse relay panel. Does that mean that the ground is fused on the fuse panel?
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
- SlowLane
- IAC Addict!
- Location: Livermore, CA
- Status: Offline
Re: Vanagon Fuel Pump Ground
Just behind and next to the fuse panel are two circular multi-prong grounding connectors screwed into the body. My guess would be that is the terminal in question. You can see these connectors if you loosen and drop the fuse panel, or if you remove the instrument cluster and look down.
Dropping the fuse panel is probably the easiest option, but disconnect your battery positive terminal first. There are some live terminals on that fuse block with nice big fat wires attached to them, and they will create some pretty exciting sparks if they happen to brush against any grounded part of the car.
Dropping the fuse panel is probably the easiest option, but disconnect your battery positive terminal first. There are some live terminals on that fuse block with nice big fat wires attached to them, and they will create some pretty exciting sparks if they happen to brush against any grounded part of the car.
'81 Canadian Westfalia (2.0L, manual), now Californiated
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Re: Vanagon Fuel Pump Ground
Thank you. My fuel pump has been cutting in and out a bit, like its hanging up or seizing. It is an old pump... probably original. I will be replacing it, just in case, and will also be running a new ground right to the body under the fuel pump.
This is for non-stock installation.
This is for non-stock installation.
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
- SlowLane
- IAC Addict!
- Location: Livermore, CA
- Status: Offline
Re: Vanagon Fuel Pump Ground
When my pump died, it just stopped. No warning, no cutting in and out. One second I was merrily cruising along, the next I was dead by the side of the road.luftvagon wrote:Thank you. My fuel pump has been cutting in and out a bit, like its hanging up or seizing. It is an old pump... probably original. I will be replacing it, just in case, and will also be running a new ground right to the body under the fuel pump.
I'll suggest you check out everything external to the pump before blindly replacing it. If you can get a voltmeter across the pump terminals and observe the voltage as it does it's cutting in and out, that might help. Use an analog VOM if you have one: a DVM may not be fast enough to catch momentary voltage drop-outs.
It's probably a worthwhile exercise to drop the fuse panel and clean up your grounds behind there anyways. A lot of grounds get terminated there, so if you suspect a problem with one ground, then there are likely to be problems with other ones.
And if you're going to go to the trouble of running a new ground for the pump, why not just run it directly to the battery negative post? It's in the same vicinity as the pump.
'81 Canadian Westfalia (2.0L, manual), now Californiated
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Re: Vanagon Fuel Pump Ground
Good idea. I checked everything on the back-end side (power-sofware-relay-power-fuse-fuel-pump), and the only thing that I could not track was the ground.SlowLane wrote:When my pump died, it just stopped. No warning, no cutting in and out. One second I was merrily cruising along, the next I was dead by the side of the road.luftvagon wrote:Thank you. My fuel pump has been cutting in and out a bit, like its hanging up or seizing. It is an old pump... probably original. I will be replacing it, just in case, and will also be running a new ground right to the body under the fuel pump.
I'll suggest you check out everything external to the pump before blindly replacing it. If you can get a voltmeter across the pump terminals and observe the voltage as it does it's cutting in and out, that might help. Use an analog VOM if you have one: a DVM may not be fast enough to catch momentary voltage drop-outs.
It's probably a worthwhile exercise to drop the fuse panel and clean up your grounds behind there anyways. A lot of grounds get terminated there, so if you suspect a problem with one ground, then there are likely to be problems with other ones.
And if you're going to go to the trouble of running a new ground for the pump, why not just run it directly to the battery negative post? It's in the same vicinity as the pump.
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
- dingo
- IAC Addict!
- Location: oregon - calif
- Status: Offline
Re: Vanagon Fuel Pump Ground
Its the AMPS you want to check. If it is above spec, then it is at the end of its life. I think 5-6 Amps is about right...higher than that is a problem. (assuming no blockage in line or filter)
'71 Kombi, 1600 dp
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Vanagon Fuel Pump Ground
I recommend that you keep the battery negative terminal/post free and clear. There is no reason the metal of the car cannot handle all electron delivery needs for a fuel pump. The negative terminal is one of those things that if you need to yank it off NOW, let it be unencumbered.SlowLane wrote: new ground for the pump, why not just run it directly to the battery negative post?
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- SlowLane
- IAC Addict!
- Location: Livermore, CA
- Status: Offline
Re: Vanagon Fuel Pump Ground
Yeah, I was just thinking out loud and stirring up s**t.Amskeptic wrote:I recommend that you keep the battery negative terminal/post free and clear. There is no reason the metal of the car cannot handle all electron delivery needs for a fuel pump.SlowLane wrote: new ground for the pump, why not just run it directly to the battery negative post?
Frankly, I figure that if VW went to the trouble of running that extra copper to the grounding block behind the fuse panel instead of just running a short jumper to the frame, they must've had a good reason (google "star-ground" and "ground-loop", ferinstance). And to reiterate, if there is a suspected ground problem at the block, I maintain it ought to be fixed there, rather than bypassing it, because who knows what other gremlins might be lurking elsewhere due to that flaky ground connection.
'81 Canadian Westfalia (2.0L, manual), now Californiated
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
"They say a little knowledge is a dangerous thing, but it is not one half so bad as a lot of ignorance."
- Terry Pratchett
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Vanagon Fuel Pump Ground
I *believe* that VW ran the fuel pump grounds to where you could diagnose the (+) and (-) in proximity to each other. That is why they went through all that ground wire junk to the double relay on the earlier buses, I *believe*.SlowLane wrote:Yeah, I was just thinking out loud and stirring up s**t.Amskeptic wrote:I recommend that you keep the battery negative terminal/post free and clear. There is no reason the metal of the car cannot handle all electron delivery needs for a fuel pump.SlowLane wrote: new ground for the pump, why not just run it directly to the battery negative post?
Frankly, I figure that if VW went to the trouble of running that extra copper to the grounding block behind the fuse panel instead of just running a short jumper to the frame, they must've had a good reason (google "star-ground" and "ground-loop", ferinstance). And to reiterate, if there is a suspected ground problem at the block, I maintain it ought to be fixed there, rather than bypassing it, because who knows what other gremlins might be lurking elsewhere due to that flaky ground connection.
ColinItsAboutFaithBasedDiagnostics
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Re: Vanagon Fuel Pump Ground
Update : Just when you think you nailed it...
I run a ground jumper. In the mean time, the power spade terminal breaks off.. No problem. That could have been my problem all along. Crimp another spade.
Problem feels solved.. but then BAM. Another event... Fuel pump is bucking.
Problem is back -- so it wasn't the ground, it wasn't the spade terminal at the fuel pump.
Go back and move the fuel pump power source so it is not computer/software switched.... BAM. Problem reproduced.
We are left with two possible culprits red/blue power cable to the fuel pump, or the fuel pump itself.
Has anyone experience such a fuel pump failure?
I run a ground jumper. In the mean time, the power spade terminal breaks off.. No problem. That could have been my problem all along. Crimp another spade.
Problem feels solved.. but then BAM. Another event... Fuel pump is bucking.
Problem is back -- so it wasn't the ground, it wasn't the spade terminal at the fuel pump.
Go back and move the fuel pump power source so it is not computer/software switched.... BAM. Problem reproduced.
We are left with two possible culprits red/blue power cable to the fuel pump, or the fuel pump itself.
Has anyone experience such a fuel pump failure?
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Vanagon Fuel Pump Ground
Classic internal electrical impending death that strikes fuel pump motors, wiper motors, starter motors, defroster motors. Many times they get intermittent as they warm up (electrically). You are the person in the position to bypass the factory red/blue wire to see if the pump now runs consistently.luftvagon wrote:Update : Just when you think you nailed it...
I run a ground jumper. In the mean time, the power spade terminal breaks off.. No problem. That could have been my problem all along. Crimp another spade.
Problem feels solved.. but then BAM. Another event... Fuel pump is bucking.
Problem is back -- so it wasn't the ground, it wasn't the spade terminal at the fuel pump.
Go back and move the fuel pump power source so it is not computer/software switched.... BAM. Problem reproduced.
We are left with two possible culprits red/blue power cable to the fuel pump, or the fuel pump itself.
Has anyone experience such a fuel pump failure?
Got a spare pump?
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- dingo
- IAC Addict!
- Location: oregon - calif
- Status: Offline
Re: Vanagon Fuel Pump Ground
How many Amps ?????
'71 Kombi, 1600 dp
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
';78 Tranzporter 2L
" Fill what's empty, empty what's full, and scratch where it itches."
-
- Old School!
- Location: Little Rock, AR
- Status: Offline
Re: Vanagon Fuel Pump Ground
dingo, I believe it's 4.5amps. I'll get an update with pictures. Everything fit perfectly. I'm even running a nice pre-filter which is common from any parts store without having to special order. Update coming tonight with pictures!
1981 Volkswagen Vanagon Westfalia - air-cooled Type4 1970cc CV (hydraulic lifters, 42x36 valves, stock cam, microSquirt FI with wasted spark ignition)
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI
1993 Ford F-250 XL LWB Extended Cab 7.3L IDI