Split CV Joint boots for bay window bus?

Moderators: Sluggo, Amskeptic

Post Reply
User avatar
JLT
Old School!
Location: Sacramento CA
Status: Offline

Split CV Joint boots for bay window bus?

Post by JLT » Fri Sep 04, 2020 1:39 pm

I guess this question goes here, because it is a drive-train issue...

While rolling around under my bus, something I love to do every now and then...

Sorry. I'll start again.

While rolling around under my bus adjusting the rear brakes, I noticed that the CV joint boots were starting to crack ... both pairs, left and right. The CV joints themselves haven't been giving me trouble.

I see a lot of vendors for the boots like the ones on the shaft, but I also seem to remember somebody who offered a split boot that you could slip on the shaft and joints without having to disassemble them. They had a half-dozen to a dozen fasteners that you tightened to seal the split. Does this sound familiar to anybody? Is there a source for them? Are they any good?

I'm suspecting that it was something that I'd seen in a JC Whitney catalog about 40 years ago, when they were selling all kinds of crap for Volkswagens.

Anyway, if these no longer are available, what are people's feelings about quality sources for the boots, clamps and grease? (They seem to come as a kit.) I am assuming the CV Joints themselves are OK.
-- JLT
Sacramento CA

Present bus: '71 Dormobile Westie "George"
(sometimes towing a '65 Allstate single-wheel trailer)
Former buses: '61 17-window Deluxe "Pink Bus"
'70 Frankenwestie "Blunder Bus"
'71 Frankenwestie "Thunder Bus"

User avatar
asiab3
IAC Addict!
Location: San Diego, CA
Contact:
Status: Offline

Re: Split CV Joint boots for bay window bus?

Post by asiab3 » Mon Sep 07, 2020 9:20 pm

I think that was a vintage attempt at installing the (non-rotating) swing axle split boots onto CV joint-equipped vehicles. Some people probably got away with it, and kits may have even been offered, but I know of nothing of the sort nowadays…

Robbie
1969 bus, "Buddy."
145k miles with me.
322k miles on Earth.

kreemoweet
Getting Hooked!
Location: Seattle
Status: Offline

Re: Split CV Joint boots for bay window bus?

Post by kreemoweet » Mon Sep 07, 2020 10:10 pm

The cvj boots need to flex at all 360 degrees. The split boots do not.
There is no need to replace boots just because of "cracks", unless the boots are
actually holed. I have some original '71 boots that were covered with surface cracks back in 1995,
and the same boots look no worse and are serving well today.

User avatar
JLT
Old School!
Location: Sacramento CA
Status: Offline

Re: Split CV Joint boots for bay window bus?

Post by JLT » Tue Sep 08, 2020 8:02 am

kreemoweet wrote:
Mon Sep 07, 2020 10:10 pm
The cvj boots need to flex at all 360 degrees. The split boots do not.
There is no need to replace boots just because of "cracks", unless the boots are
actually holed.
These are cracked all the way through. It's replacement time.

Who are the good suppliers, and which ones would you stay away from?
-- JLT
Sacramento CA

Present bus: '71 Dormobile Westie "George"
(sometimes towing a '65 Allstate single-wheel trailer)
Former buses: '61 17-window Deluxe "Pink Bus"
'70 Frankenwestie "Blunder Bus"
'71 Frankenwestie "Thunder Bus"

User avatar
Amskeptic
IAC "Help Desk"
IAC "Help Desk"
Status: Offline

Re: Split CV Joint boots for bay window bus?

Post by Amskeptic » Thu Sep 10, 2020 7:31 pm

JLT wrote:
Tue Sep 08, 2020 8:02 am
kreemoweet wrote:
Mon Sep 07, 2020 10:10 pm
The cvj boots need to flex at all 360 degrees. The split boots do not.
There is no need to replace boots just because of "cracks", unless the boots are
actually holed.
These are cracked all the way through. It's replacement time.

Who are the good suppliers, and which ones would you stay away from?
I have had good luck with Reinz. These are at 70,000 miles now. Wash them with mild dishwashing detergent every now and then, rinse well. They will last a long time.
Colin

Image
BobD - 78 Bus . . . 112,660 miles
Chloe - 70 bus . . . 206,845 miles
Naranja - 77 Westy . . . 121,400 miles
Pluck - 1973 Squareback . . . . . . 55,570 miles
Alexus - 91 Lexus LS400 . . . 92,435 miles

User avatar
skip
I'm New!
Location: Englewood, NJ
Status: Offline

Re: Split CV Joint boots for bay window bus?

Post by skip » Fri Sep 11, 2020 6:15 am

Complexity is the enemy of reliability.

76 Westfalia
74 Type 181

Post Reply