Stiff ignition
-
- Getting Hooked!
- Status: Offline
Stiff ignition
Hello kind forum,
Simply put: my ignition is getting stiff. When I turn the key to start the bus, there's some resistance. It kind of feels like there's some gunk in there that prevents the smooth operation of the ignition.
Can I spray some silicone into the key slot? WD-40?
Thanks,
James
Simply put: my ignition is getting stiff. When I turn the key to start the bus, there's some resistance. It kind of feels like there's some gunk in there that prevents the smooth operation of the ignition.
Can I spray some silicone into the key slot? WD-40?
Thanks,
James
- Bleyseng
- IAC Addict!
- Location: Seattle again
- Contact:
- Status: Offline
Re: Stiff ignition
I'd take it apart, not the plastic ignition switch with the wires but the rest of it. Clean and new light grease
Geoff
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
77 Sage Green Westy- CS 2.0L-160,000 miles
70 Ghia vert, black, stock 1600SP,- 139,000 miles,
76 914 2.1L-Nepal Orange- 160,000+ miles
http://bleysengaway.blogspot.com/
-
- Getting Hooked!
- Status: Offline
Re: Stiff ignition
I have an early bus (69). Do I have to remove the steering column to get at the assembly?
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Stiff ignition
Feel free to do a little squirt of WD-40 at the top of the circle of the key cylinder as you turn it. Also, do a little wetten of the key teeth before your insert it. If you can get a WD-40 straw between the steering wheel and the turn signal switch bezel just over the key area where you think the deadbolt is located, squirt between the steering shaft and column, then turn the wheel back and forth a bit, remove key, see if you get a steering lock. If yes, only turn the key to unlock AS you pull against the steering wheel to unload the deadbolt.
If the above yields no improvement, then yes, the early bus has a more diabolical disassembly process waiting with your name on it.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- Addicted!
- Status: Offline
Re: Stiff ignition
I might suggest using a bit of graphite lube that’s made for locks. I was experiencing an ignition that would sometimes just get stuck and wouldn’t turn at all. Then sprayed a bit of graphite into the barrel and it’s been working perfect ever since.
- asiab3
- IAC Addict!
- Location: San Diego, CA
- Contact:
- Status: Offline
Re: Stiff ignition
The early bay key switch assembly has two main components: the mechanical lock cylinder and the electrical switch portion. It would be worth pulling the electrical portion out (because it’s easy) and trying the mechanical cylinder by itself to isolate where the problem lies.
On an early early bay (pre-71?) two SMALL screws hold the electrical components in after you’ve removed the four large Phillips head screws under the steering column support and tilted the wheel/column back a few inches. I would disconnect the battery first, because there is an unfused hot wire in there.
Robbie
On an early early bay (pre-71?) two SMALL screws hold the electrical components in after you’ve removed the four large Phillips head screws under the steering column support and tilted the wheel/column back a few inches. I would disconnect the battery first, because there is an unfused hot wire in there.
Robbie
1969 bus, "Buddy."
145k miles with me.
322k miles on Earth.
145k miles with me.
322k miles on Earth.
-
- Getting Hooked!
- Status: Offline
Re: Stiff ignition
OK, thanks all.
I will try the WD-40 and graphite remedies and see if that loosens things up. The weather here in NJ promises maybe another two weeks of bus driving, then we tuck it away until the first big rain of the spring washes away all the road salt of winter. I'll wait for next year for more invasive measures.
Projects for the winter include recovering the drivers seat and maybe finally getting back to the guy who offered a spare engine from a 73/74 Ghia:
viewtopic.php?f=3&t=13457
Dreaming of warm weather...
James
I will try the WD-40 and graphite remedies and see if that loosens things up. The weather here in NJ promises maybe another two weeks of bus driving, then we tuck it away until the first big rain of the spring washes away all the road salt of winter. I'll wait for next year for more invasive measures.
Projects for the winter include recovering the drivers seat and maybe finally getting back to the guy who offered a spare engine from a 73/74 Ghia:
viewtopic.php?f=3&t=13457
Dreaming of warm weather...
James
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Stiff ignition
appetite wrote: ↑Tue Oct 30, 2018 3:00 pmOK, thanks all.
I will try the WD-40 and graphite remedies and see if that loosens things up. The weather here in NJ promises maybe another two weeks of bus driving, then we tuck it away until the first big rain of the spring washes away all the road salt of winter. I'll wait for next year for more invasive measures.
Projects for the winter include recovering the drivers seat and maybe finally getting back to the guy who offered a spare engine from a 73/74 Ghia:
viewtopic.php?f=3&t=13457
Dreaming of warm weather...
James
No graphite at the ignition switch, it can cause shorts. Just do the WD-40 and report back. Next step is a non-graphite disassembly and lubrication with silicone grease near the plastic bits and good moly at the deadbolt.
Ghia engine is only a possible IF it has the mounting holes in the case for your mustache bar. Type 2, Type 3, and universal cases have those critical mounting holes. If it does not have the three factory mounting holes (with factory supplied steel threaded inserts!) NO.
James? No.
No oil pump adapter allowed.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- Addicted!
- Status: Offline
Re: Stiff ignition
Well I’d listen to Colin on the sticky lock but no ill effects using graphite on mine so far. I have always heard to only use graphite because anything else eventually gums up and gets sticky again.
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Stiff ignition
71whitewesty wrote: ↑Wed Oct 31, 2018 8:31 amWell I’d listen to Colin on the sticky lock but no ill effects using graphite on mine so far. I have always heard to only use graphite because anything else eventually gums up and gets sticky again.
Graphite is excellent and is called-for for all door locks on the exterior because of what you wrote, yes.
Graphite is potentially dangerous if it falls into the ignition switch and causes a conductive track between let's say #30 and #50 at 55 mph. You wouldn't necessarily hear it up in the driver's seat.
"Daddy, what's that sound?"
"Be quiet kid, you bother me."
"But . . . "
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- Getting Hooked!
- Status: Offline
Re: Stiff ignition
Reporting back on this issue...
After a week of rain, all of the road salt has been washed away and today's temps were perfect for taking the bus out of hibernation for the first time this season.
After installing the battery, checking fuel lines and dutifully performing other sundry maintenance chores, I addressed the stiff ignition as per Colin's advice, with some squirts of WD40. Perhaps the squirts were too generous: on our inaugural ride, I had a bit of a drip of the slippery stuff rolling down the steering column.
Still, the twist of the key is smoother and less, well, stiff.
Hoping that's all there is to it.
James
After a week of rain, all of the road salt has been washed away and today's temps were perfect for taking the bus out of hibernation for the first time this season.
After installing the battery, checking fuel lines and dutifully performing other sundry maintenance chores, I addressed the stiff ignition as per Colin's advice, with some squirts of WD40. Perhaps the squirts were too generous: on our inaugural ride, I had a bit of a drip of the slippery stuff rolling down the steering column.
Still, the twist of the key is smoother and less, well, stiff.
Hoping that's all there is to it.
James
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Stiff ignition
appetite wrote: ↑Sun Mar 24, 2019 3:09 pmReporting back on this issue...
After a week of rain, all of the road salt has been washed away and today's temps were perfect for taking the bus out of hibernation for the first time this season.
After installing the battery, checking fuel lines and dutifully performing other sundry maintenance chores, I addressed the stiff ignition as per Colin's advice, with some squirts of WD40. Perhaps the squirts were too generous: on our inaugural ride, I had a bit of a drip of the slippery stuff rolling down the steering column.
Still, the twist of the key is smoother and less, well, stiff.
Hoping that's all there is to it.
James
And that is all there is to it . . .
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
- Kubelwagen
- Addicted!
- Location: Portland, OR
- Status: Offline
Re: Stiff ignition
...and in my experience likely to get better as you use it and the greasy goodness makes it’s way through they system.
I guess Gypsie doesn’t get around here much anymore.
I guess Gypsie doesn’t get around here much anymore.
Patience the 81 Adventurewagen
- Amskeptic
- IAC "Help Desk"
- Status: Offline
Re: Stiff ignition
Speaking of greasy goodness? Ewwwwwwwwww.Kubelwagen wrote: ↑Mon Apr 01, 2019 3:43 pm...and in my experience likely to get better as you use it and the greasy goodness makes it’s way through they system.
I guess Gypsie doesn’t get around here much anymore.
Colin
BobD - 78 Bus . . . 112,730 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
Chloe - 70 bus . . . 217,593 miles
Naranja - 77 Westy . . . 142,970 miles
Pluck - 1973 Squareback . . . . . . 55,600 miles
Alexus - 91 Lexus LS400 . . . 96,675 miles
-
- Getting Hooked!
- Status: Offline
Re: Stiff ignition
Following up on this repair.
WD40 in generous amounts was the remedy. Worked wonders.
Thanks Colin.
WD40 in generous amounts was the remedy. Worked wonders.
Thanks Colin.